[1]赵丽娟,邵启运,解清杰.反渗透在不锈钢制品生产废水零排放工程中的应用[J].中国给水排水,2021,37(17):94-99.
ZHAO Li-juan,SHAO Qi-yun,XIE Qing-jie.Application of Reverse Osmosis for Treatment of Stainless Steel Production Wastewater in a Zero Discharge Project[J].China Water & Wastewater,2021,37(17):94-99.
反渗透在不锈钢制品生产废水零排放工程中的应用
- Title:
- Application of Reverse Osmosis for Treatment of Stainless Steel Production Wastewater in a Zero Discharge Project
- 作者:
- 赵丽娟1，邵启运2，解清杰2
- (1.张家口市城乡建设规划设计院，河北张家口075000；2.江苏大学环境与安全工程学院，江苏镇江212013)
- Author(s):
- ZHAO Li-juan1,SHAO Qi-yun2,XIE Qing-jie2
- (1. Zhangjiakou Urban and Rural Construction Planning and Design Institute， Zhangjiakou 075000， China； 2. College of Environmental and Safty Engineering， Jiangsu University， Zhenjiang 212013， China)
- 摘要:
- 以某不锈钢制品企业生产废水为研究对象，针对其酸度高、毒性强、产量大、难处理的水质特征，设计了以反渗透工艺为核心的基于“预处理+反渗透+MVR”组合的零排放工艺。运行结果表明，在一、二、三段运行压力分别为1.2、1.7、2.2 MPa和浓水回流量均为50%的条件下，经过反渗透系统的处理，废水的电导率由2 075~2 133 μS/cm稳定降低至30 μS/cm以下；对COD、NH3-N、TN、TP的平均去除率分别为88%、65%、88%、97%以上；废水回收率基本保持在87％~92％之间，系统总脱盐率达到98%以上。零排放系统总的运行费用为56.83元/m3，反渗透系统的运行费用为5.35元/m3，综合收益达13.08万元/年。
- Abstract:
- As the wastewater from a stainless steel production enterprise is characterized by high acidity, strong toxicity, large flow rate and difficult to treat, a zero discharge project based on the combined process of pretreatment, reverse osmosis and MVR was designed with reverse osmosis process as the core technology. When the operating pressures of the first, second and third stages were 1.2 MPa, 1.7 MPa and 2.2 MPa, respectively, and the reflux rate of the concentrated water was 50%, the conductivity of the wastewater decreased steadily from 2 075-2 133 μS/cm to less than 30 μS/cm after treatment by the reverse osmosis system. The average removal efficiencies of COD, NH3-N, TN and TP were above 88%, 65%, 88% and 97%, respectively. The recovery rate of the wastewater was between 87% and 92%, and the total desalination rate of the system was above 98%. The total operating cost of the zero discharge system was 56.83 yuan/m3, among which the operating cost of the reverse osmosis system was 5.35 yuan/m3. The comprehensive income of the process reached 130 800 yuan/year.
相似文献/References:
[1]赵健忠,王学华,王浩,等.浙江某印染废水处理工程改造及分析[J].中国给水排水,2020,36(14):134.
ZHAO Jian-zhong,WANG Xue-hua,WANG Hao,et al.Reconstruction and Analysis of a Printing and Dyeing Wastewater Treatment Project in Zhejiang[J].China Water & Wastewater,2020,36(17):134.
[2]马跃龙,徐瑶瑶,刘宁,等.SBR/RO工艺源分离尿液处理特性研究[J].中国给水排水,2020,36(21):7.
MA Yue-long,XU Yao-yao,LIU Ning,et al.Treatment Characteristics of Source-separated Urine by SBR/RO Process[J].China Water & Wastewater,2020,36(17):7.
[3]周明飞,连坤宙,王璟,等.电渗析技术处理脱硫废水的效果分析[J].中国给水排水,2020,36(21):80.
ZHOU Ming-fei,LIAN Kun-zhou,WANG Jing,et al.Efficiency Analysis of Desulfurization Wastewater Treated by Electrodialysis Technology[J].China Water & Wastewater,2020,36(17):80.
[4]岳丽芳,王春慧,韩一杰,等.钢铁企业浓盐水处理回用工程实例[J].中国给水排水,2020,36(22):156.
YUE Li-fang,WANG Chun-hui,HAN Yi-jie,et al.Brine Treatment and Reuse Project of an Iron and Steel Enterprise[J].China Water & Wastewater,2020,36(17):156.
[5]王金龙.再生水厂UF-RO双膜工艺的设计探讨及优化改进[J].中国给水排水,2020,36(24):120.
WANG Jin-long.Discussion and Improvement on Design of UF and RO Process in a Water Reclamation Plant[J].China Water & Wastewater,2020,36(17):120.
[6]李东洋,汪程鹏,王生辉,等.海岛反渗透海水淡化透平式能量回收技术工程应用[J].中国给水排水,2020,36(24):130.
LI Dong-yang,WANG Cheng-peng,WANG Sheng-hui,et al.Application of Turbine Energy Recovery Technology in an Island Reverse Osmosis Desalination Project[J].China Water & Wastewater,2020,36(17):130.
[7]孙江虎.脱盐水站浓水反渗透系统的节水改造[J].中国给水排水,2021,37(12):156.
SUN Jiang-hu.Water Saving Retrofit of Concentrated Water RO System in a Desalted Water Station[J].China Water & Wastewater,2021,37(17):156.
[8]孙爱华,陈波,刘慎.IOC—A/O—UF/NF/RO组合工艺处理垃圾焚烧渗滤液[J].中国给水排水,2021,37(16):112.
SUN Ai-hua,CHEN Bo,LIU Shen.Treatment of Leachate from Waste Incineration Plant by a Combined Process of IOC, A/O, and UF/NF/RO[J].China Water & Wastewater,2021,37(17):112.
[9]李长海,张雅潇,普建国,等.生物法+膜法工艺处理垃圾焚烧电厂渗滤液[J].中国给水排水,2022,38(2):104.
LI Chang?hai,ZHANG Ya?xiao,PU Jian?guo,et al.Treatment of Leachate from Waste Incineration Power Plant by Biological and Membrane Process[J].China Water & Wastewater,2022,38(17):104.
[10]孙铎,吴刚,朱先征,等.TFC和TFN反渗透膜处理半导体废水的性能对比[J].中国给水排水,2026,42(1):22.
SUN Duo,WU Gang,ZHUXianzheng,et al.Performance Comparison of TFC and TFN Reverse Osmosis Membranes in Treating Semiconductor Wastewater[J].China Water & Wastewater,2026,42(17):22.
