LUO Feng,PENG Jin?hu,ZHANG Zhong-xiang,et al.Preparation of Carbon Source by Anaerobic Fermentation of Sludge in Wastewater Treatment Plant in Southern China and Its Dosing Strategy[J].China Water & Wastewater,2022,38(3):1-6.
南方污水处理厂污泥厌氧发酵制取碳源及投加策略
- Title:
- Preparation of Carbon Source by Anaerobic Fermentation of Sludge in Wastewater Treatment Plant in Southern China and Its Dosing Strategy
- Keywords:
- excess sludge; anaerobic fermentation; carbon source; biological nitrogen removal; sludge reduction
- 摘要:
- 为应对污水厂出水总氮标准日益提升的要求，提高生化池的反硝化能力，减少对外加碳源的依赖，考察了利用南方某污水处理厂的剩
余污泥厌氧发酵制取碳源的效能、影响因素和回用投加比例，分析了剩余污泥厌氧发酵制取碳源的可行性、污泥减量效果和经济效益。当控制初始MLSS约为15 000 mg/L时，厌氧发酵的ORP基本在-400 mV左右，有利于碳源的制取；可采用按比例更换新污泥的方式进行厌氧发酵，换泥比例为每天50%左右，折合SRT约为48 h；以2.5%厌氧发酵污泥结合75 mg/L复合碳源投加到缺氧系统中，可增强脱氮能力，且发酵污泥的总氮、总磷和重金属离子基本不会对生化系统造成不良影响。以折合SRT计算，厌氧发酵的污泥削减率约为7%；以10×104 m3/d的污水处理厂为例，采用厌氧发酵技术每年可节省运营成本约410.6 万元。
Abstract:- In order to meet the increasing demand of the total nitrogen standard of effluent from wastewater treatment plant (WWTP), enhance the denitrification capacity of biochemical tank and reduce the dependence on the external carbon source, the influencing factors of carbon source preparation by anaerobic fermentation of excess sludge from a WWTP in Southern China and the ratio of reuse were investigated. The feasibility, sludge reduction and economic benefit were analyzed. When the initial MLSS was controlled at about 15 000 mg/L, the ORP was about -400 mV during anaerobic fermentation, which was beneficial to the preparation of carbon source. Anaerobic fermentation was carried out by replacing new sludge in proportion, and the replacement ratio was about 50% per day, in which sludge retention time was about 48 hours. 2.5% anaerobic fermentation sludge combined with 75 mg/L composite carbon source was added to the anoxic system to enhance the nitrogen removal capacity, and the total nitrogen, total phosphorus and heavy metal ions of sludge would not cause adverse effects on the biochemical system. Based on SRT, the sludge reduction rate of anaerobic fermentation was about 7%. Taking a WWTP with capacity of 10×104 m3/d as an example, the adoption of anaerobic fermentation technology could save operating cost about 4.106 million yuan each year.
相似文献/References:
[1]徐志嫱,李瑶,周爱朝,等.污泥热水解过程中磷的释放规律与影响因素[J].中国给水排水,2018,34(21):24.
XU Zhi qiang,LI Yao,ZHOU Ai chao,et al.Phosphate Release and Influencing Factors Analysis during Sludge Thermal Hydrolysis[J].China Water & Wastewater,2018,34(3):24.
[2]张彦平,呼瑞琪,李一兵,等.高铁酸盐氧化剩余污泥溶胞减量研究[J].中国给水排水,2020,36(15):59.
ZHANG Yan-ping,HU Rui-qi,LI Yi-bing,et al.Lysis and Reduction of Excess Sludge by Ferrate Oxidation[J].China Water & Wastewater,2020,36(3):59.
[3]胡德秀,张聪,张艳.超声强化污泥释磷及MAP法磷回收优化研究[J].中国给水排水,2020,36(15):65.
HU De-xiu,ZHANG Cong,ZHANG Yan.Phosphorus Release from Sludge Enhanced by Ultrasound and Optimization of Phosphorus Recovery by Magnesium Ammonium Phosphate Method[J].China Water & Wastewater,2020,36(3):65.
[4]晏习鹏,肖小兰,亓金鹏,等.中试厌氧膜生物反应器对剩余污泥的消化效果[J].中国给水排水,2020,36(19):1.
YAN Xi-peng,XIAO Xiao-lan,QI Jin-peng,et al.Digestion of Excess Sludge in a Pilot Anaerobic Membrane Bioreactor[J].China Water & Wastewater,2020,36(3):1.
[5]孙洋洋,张雨辰,徐苏云.不同来源剩余污泥有机质赋存特征及厌氧消化潜能[J].中国给水排水,2021,37(11):17.
SUN Yang-yang,ZHANG Yu-chen,XU Su-yun.Characteristics of Organic Matters in Excess Sewage Sludge from Different Sources and Their Anaerobic Digestion Potential[J].China Water & Wastewater,2021,37(3):17.
[6]朱赵冉,黄显怀,唐玉朝,等.低速搅拌球磨破解剩余污泥高效释放碳源[J].中国给水排水,2021,37(13):1.
ZHU Zhao-ran,HUANG Xian-huai,TANG Yu-chao,et al.High Efficient Release of Carbon Source from Excess Sludge Disintegrated by Low-speed Stirring and Ball-milling[J].China Water & Wastewater,2021,37(3):1.
[7]赵博玮,牛宇锟,谢飞,等.剩余污泥碳化裂解液的资源化中试研究[J].中国给水排水,2021,37(19):1.
ZHAO Bo-wei,NIU Yu-kun,XIE Fei,et al.Pilot-scale Study on Resource Recycling of Excess Sludge Carbonized Pyrolysis Liquid[J].China Water & Wastewater,2021,37(3):1.
[8]窦川川,刘玉玲,赵鹏鹤,等.碱预处理对剩余污泥DOM的溶出特征及平行因子分析[J].中国给水排水,2021,37(19):14.
DOU Chuan-chuan,LIU Yu-ling,ZHAO Peng-he,et al.Effect of Alkaline Pretreatment on DOM Dissolution Characteristics of Excess Sludge and Parallel Factor Analysis[J].China Water & Wastewater,2021,37(3):14.
[9]罗璐,施周,许仕荣,等.溶菌酶预处理对剩余污泥脱水性能的影响[J].中国给水排水,2022,38(3):87.
LUOLu,SHIZhou,XUShi-rong,et al.Effect of Lysozyme Pretreatment on Dewatering Performance of Excess Activated Sludge[J].China Water & Wastewater,2022,38(3):87.
[10]刘子娟,王寅义,徐肖甜,等.剩余污泥碱性发酵产酸及脱水性能研究[J].中国给水排水,2022,38(3):92.
LIUZi-juan,WANG Yin-yi,XUXiao-tian,et al.Acid Production and Dewatering Performance of Excess Sludge with Alkaline Fermentation[J].China Water & Wastewater,2022,38(3):92.
