XIAODong-jie,LIULi-zhu,LIFang-zhi.Analysis on Thermal Energy of a Sludge Treatment Project Adopting Thermal Hydrolysis and Anaerobic Digestion Process[J].China Water & Wastewater,2023,39(11):122-126.
某热水解+厌氧消化污泥处理工程热能浅析
- Title:
- Analysis on Thermal Energy of a Sludge Treatment Project Adopting Thermal Hydrolysis and Anaerobic Digestion Process
- 摘要:
- 以采用“热水解+高温厌氧消化+板框脱水+带式干化”工艺的某市政污泥集中处置工程为例，收集该工程一个自然年内的生产进泥泥质、沼气产量及各工段热能消耗等实际生产数据，分析泥质变化趋势与不同运行方式下的热能平衡情况。结果表明，污泥有机质与含固率呈季节性变化。当有机质含量为30%~46.16%的污泥采用全工艺链处理时，处理1 t干污泥（DS）需补充沼气19~92 m3，工程方可实现热能平衡。不考虑带式干化时，污泥有机质含量应高于36.88%方可保证工程能量平衡。高湿度季节以外的清灰作业可有效避免锅炉受热面积灰导致的短期锅炉热效率下降，并防止因积灰回潮导致的受热面整体腐蚀。
- Abstract:
- This paper collected the actual operational data of a municipal sludge centralized disposal project with process consisting of thermal hydrolysis, high temperature anaerobic digestion, plate frame dewatering and belt drying in a natural year, such as the quality of sludge, biogas yield and thermal energy consumption of each section, and analyzed the variation of sludge quality and the thermal energy balance under different operational modes. The organic matter and solid content of the sludge changed seasonally. When the sludge with organic matter content of 30%-46.16% was treated in the whole process chain, biogas with volume of 19-92 m3 should be added to treat each ton of dry sludge (DS), so that the project could achieve thermal energy balance. When the belt drying was not operated, the organic matter content of the sludge should be higher than 36.88% to achieve the thermal energy balance of the system. The ash-cleaning outside the season of high humidity effectively avoided the short?term reduction of boiler thermal efficiency caused by ash accumulation on boiler heating surface and prevented the overall corrosion of heating surface caused by moisture regain of accumulated ash.
相似文献/References:
[1]刘常青,陈琬,曾艺芳,等.SARD与CSTR反应器半连续发酵产氢能力对比[J].中国给水排水,2018,34(21):7.
LIU Chang qing,CHEN Wan,ZENG Yi fang,et al.Hydrogen Production Capacity of Semi continuous Fermentation of SARD and CSTR Bio hydrogen Production Reactor[J].China Water & Wastewater,2018,34(11):7.
[2]颜莹莹,梁远,沙雪华,等.新冠肺炎疫情下关于减少污泥中病原体的思考[J].中国给水排水,2020,36(6):22.
[3]郭波,田瑜,范晨,等.绿色纳米铁/H2O2联用两性脱水剂调理污泥研究[J].中国给水排水,2020,36(13):62.
GUO Bo,TIAN Yu,FAN Chen,et al. Sludge Conditioning by Green Iron Nanoparticles/H2O2 Combined with Amphoteric Dewatering Agent [J].China Water & Wastewater,2020,36(11):62.
[4]许劲,范准,吕秋颖,等.山地城市污泥水热炭化产物特性研究[J].中国给水排水,2020,36(21):21.
XU Jin,FAN Zhun,L Qiu-ying,et al.Characteristics of Hydrothermal Carbonization Products of Municipal Sludge in Mountainous Cities[J].China Water & Wastewater,2020,36(11):21.
[5]李金河,张波涛,刘宝玉,等.污泥中温厌氧消化最佳温度及改善机理分析[J].中国给水排水,2021,37(3):9.
LI Jin-he,ZHANG Bo-tao,LIU Bao-yu,et al.Optimal Reaction Temperature in Mesophilic Anaerobic Digestion of Waste Activated Sludge and Its Promotion Mechanism[J].China Water & Wastewater,2021,37(11):9.
[6]王丽花,吕国钧,王飞,等.污泥干化焚烧系统的节能降耗研究[J].中国给水排水,2021,37(4):29.
WANG Li-hua,Lü Guo-jun,WANG Fei,et al.Research on Energy Saving and Consumption Reduction of Sludge Drying and Incineration System[J].China Water & Wastewater,2021,37(11):29.
[7]纪莎莎,黄瑾.污泥焚烧工程中的磷形态分布与磷迁移研究[J].中国给水排水,2021,37(5):26.
JI Sha-sha,HUANG Jin.Phosphorus Forms Distribution and Migration in Sludge Incineration Project[J].China Water & Wastewater,2021,37(11):26.
[8]马彩霞,刘蕾,李碧清,等.强化化学淋滤对污泥重金属溶出及磷释放的影响[J].中国给水排水,2021,37(5):66.
MA Cai-xia,LIU Lei,LI Bi-qing,et al.Effect of Enhanced Chemical Leaching on Heavy Metal Dissolution and Phosphorus Release from Sludge[J].China Water & Wastewater,2021,37(11):66.
[9]李伟,常菁,王佳伟,等.热水解高级厌氧消化系统的污泥消毒、减量与能量回收[J].中国给水排水,2021,37(16):19.
LI Wei,CHANG Jing,WANG Jia-wei,et al.Sludge Disinfection, Reduction and Energy Recovery by Anaerobic Digestion with Thermal Hydrolysis Pretreatment[J].China Water & Wastewater,2021,37(11):19.
[10]胡佩佩,侯锋,范莹,等.深度脱水污泥好氧发酵工艺研究[J].中国给水排水,2021,37(17):74.
HU Pei-pei,HOU Feng,FAN Ying,et al.Aerobic Fermentation Process of Deep Dewatering Sludge[J].China Water & Wastewater,2021,37(11):74.
