[1]张衷译,赵宇,王劲,等.耦合电化学系统处理膜浓缩废水的性能和机理[J].中国给水排水,2026,42(9):94-100. 

　ZHANGZhongyi,ZHAOYu,WANGJin,et al.Performance and Mechanism of Coupled Electrochemical System for Treating Membrane Concentrate Wastewater[J].China Water & Wastewater,2026,42(9):94-100. 

点击复制 

 

 

耦合电化学系统处理膜浓缩废水的性能和机理

 

 

中国给水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第42卷 期数: 2026年第9期 页码: 94-100 栏目:  出版日期: 2026-05-01 

Title:Performance and Mechanism of Coupled Electrochemical System for Treating Membrane Concentrate Wastewater作者:张衷译1， 赵宇1,2， 王劲3， 张爽1， 潘阳4， 赵泽雨1， 杨心名1（1.中国石油集团安全环保技术研究院有限公司，北京 102206；2.中国石油集团渤海石油装备制造有限公司，天津 300450；3.中国石油国际勘探开发有限公司，北京 100034；4.南京环保产业创新中心有限公司，江苏 南京 211102）Author(s):ZHANG　Zhongyi1， ZHAO　Yu1，2， WANG　Jin3， ZHANG　Shuang1， PAN　Yang4， ZHAO　Zeyu1， YANG　Xinming1（1. CNPC Research Institute of Safety and Environmental Technology， Beijing 102206， China； 2. CNPC Bohai Petroleum Equipment Manufacturing Co. Ltd.， Tianjin 300450， China； 3. China National Oil and Gas Exploration and Development Co. Ltd.， Beijing 100034， China； 4. Nanjing Innovation Center for Environmental Protection Industry Co. Ltd.， Nanjing 211102， China）关键词:膜浓缩废水;  耦合电化学系统;  除碳;  脱氮;  解毒Keywords:membrane concentrate wastewater;  coupled electrochemical system;  carbon removal;  nitrogen removal;  detoxification摘要:构建了一种电还原-电氧化耦合电化学系统，评估了其处理膜浓缩液的脱氮、除碳和解毒效能。在运行时间为3 h、电流密度为20 mA/cm2条件下，耦合电化学系统对TOC的去除率为（68.4±1.5）%，对TN的去除率为（42.7±1.7）%，较同步还原氧化系统分别提升42.8和32.4个百分点。该耦合电化学系统避免了氧化活性自由基与还原活性自由基的相互消耗、抵消，实现了还原与氧化作用的协同增效。同时，耦合电化学系统还原路径的有效发挥，实现了氧化氯化副产物的还原脱氯，显著强化了系统解毒效能，可使发光细菌抑制率从（57.6±2.0）%进一步降至（28.7±1.4）%。此外，直接还原脱氮（NO3-至N2）与直接氧化脱氮（NH4+至N2）的循环往复交替，也促进了脱氮效能的显著增强。TOC与TN协同去除效能的有效强化也进一步削减了废水的生物急性毒性。因此，该耦合电化学系统可用于高盐膜浓缩废水处理。Abstract:A coupled electroreduction-electrooxidation electrochemical system was constructed, and its performance in treating membrane concentrate was evaluated in terms of nitrogen removal, carbon removal, and detoxification. After 3 hours of operation at a current density of 20 mA/cm2, the removal rates of TOC and TN by the coupled electrochemical system were (68.4±1.5)% and (42.7±1.7)%, respectively, which were 42.8 percentage points and 32.4 percentage points higher than those of the simultaneous redox system. The coupled electrochemical system avoided mutual depletion and counteraction between oxidizing and reducing active radicals, achieving a synergistic effect between reduction and oxidation. Meanwhile, the effective functioning of the reduction pathway enabled the reductive dechlorination of oxidized chlorinated by-products, significantly enhancing the detoxification efficiency of the system and further reducing the inhibition rate of luminescent bacteria from (57.6±2.0)% to (28.7±1.4)%. Furthermore, the alternating cycle of direct reduction for TN removal (NO3- to N2) and direct oxidation for TN removal (NH4+ to N2) also significantly promoted nitrogen removal efficiency. The enhanced synergistic performance of TOC and TN removal further reduced the bio-acute toxicity of the treated wastewater. Therefore, this coupled electrochemical system can be used for the treatment of high-salinity membrane concentrate wastewater.

 

 

相似文献/References:

 

[1]周洋洋,陈茜,冉宗信,等.造粒流化床系统用于石化企业膜浓缩废水处理[J].中国给水排水,2025,41(4):126.

　ZHOUYang-yang,CHENQian,RANZong-xin,et al.Application of Granulated Fluidized Bed System in the Treatment of Membrane Concentrated Wastewater in Petrochemical Enterprises[J].China Water & Wastewater,2025,41(9):126.

 

 

更新日期/Last Update: 2026-05-01